한국세라믹학회지 (Journal of the Korean Ceramic Society)

  • 제36권4호
  • /
  • Pages.391-402
  • /
  • 1999
  • /
  • 1229-7801(pISSN)
  • /
  • 2234-0491(eISSN)
한국세라믹학회 (The Korean Ceramic Society)
권호 표지

졸-겔 코팅에 의한 저온형 고체산화물 연료저지용 전해질막의 합성 및 특성

Synthesis of Electrolyte Films for Low-Temperature Solid Oxide Fuel Cells by Sol-Gel Coating and Their Characteristics

  • 현상훈 (연세대학교 세라믹공학과) ;
  • 김승구 (연세대학교 세라믹공학과) ;
  • 장운석 (연세대학교 세라믹공학과)
  • 발행 : 1999.04.01
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

Characteristics of composite electrolytes which were prepared by coating a thin film of YSZ (yttria sta-bilized zirconia : (ZrO2)0.92 (Y2O3)0.08) on YDC (yttria doped ceria : Ce0.8Y0.2O1.9) with mixed conductivity have been investigated in order to develop the low-temperature solid oxide fuel cell. The thickness (t) of spin-coated YSZ thin films after the heat-treatment at 600$^{\circ}C$ was increased proportionally to the sol con-centrations (C) while the decrease in its thickness with the spin rate ($\omega$) could be expressed in the e-quation of ln t=9.49-0.53 ln $\omega$(0.99mol//s sol conc.) When the sol concentration and the spin rate being less than 0.99 mol/l and higher than 1000 rpm respectively reliable YSZ/YDC composite electrolytes could be obtained by multi-coating although several micro-cracks were observed in singly coated YSZ film surfaces. The dense YSZ film with a 1$\mu\textrm{m}$ thickness was prepared by coating of 0.99 mol/l YSZ sol five-times at 2000 rpm followed by heat-treatment at 1400$^{\circ}C$ for 2h, The adhesion between YSZ film and YDC substrate was found to be very good. The open circuit voltages of H2/O2 single cell with YSZ/YDC composite electrolytes were 0.79∼0.82 V at 800$^{\circ}C$ and 0.75∼0.77V at 900$^{\circ}C$ The open circuit voltage was inversely proportioned to the thickness ratio of YSZ thin film (1$\mu\textrm{m}$) to YDC substrate(0.28-2.22 mm)

키워드

참고문헌

  1. J. Am. Ceram. Soc. v.76 Ceramic Fuel Cells N.Q. Minh
  2. Science and Technology of Ceramic Fuel Cells N.Q. Minh
  3. J. Electrochem. Soc. v.122 Oxygen Ion Conduction of the Fluoride-Type $Ce_{1-x} LnxO_{2-x}$ ₂(Ln-Lanthanoid Element) T. Kudo;H. Obayashi
  4. Solid State Ionics v.52 The Possible Use of Mixed Ionic Electronic Conductors Instead of Electrolytes in Fuel Cells I. Riess
  5. Solid State Ionics v.52 Enhanced Ceria-A Low Temperature SOFC Electrolyte D.L. Maricle;T.E. Swarr;S. Karavolis
  6. Solid State Ionics v.56 Ceria-Based Solid Electrolytes H. Inaba;H. Tagawa
  7. Oxide Ceramics E. Ryshkewitck;D.W. Richerson
  8. J. Electrochem. Soc. v.138 Theoretical Analysis of Solid Oxide Fuel Cells with Two-Layer, Composite Electrolyte: Electrolyte Stability A.V. Virkar
  9. Solid State Ionics v.90 Performance of Double Layer Electrolyte Cells Part Ⅰ: Medel Behavior F.M. B. Marques;L.M. Navaro
  10. Solid State Ionics v.100 Performance of Double Layer Electrolyte Cells Part Ⅱ: GCO/YSZ, a Case Study F.M.B. Marques;L.M. Navaro
  11. J. Electrochem. Soc. v.135 High Temperature Fuel Cell with Ceria-Yttria Solid Electrolyte H. Yahiro;Y. Baba;K. Eguchi;H.Arai
  12. Sold State Ionics v.52 Electrical Properties of Ceria-Based Oxides and Their Application to Solid Oxide Fuel Cells K. Eguchi;T. Sctoguchi;T. Inoue;H. Arai
  13. Proceeding of the 3rd International Symposium on Solid Oxide Fuel Cells Fabrication and Characterization of YSZ-Coated Ceria Electrolytes K. Metha;S.J. Hong;J.F. Jue;A.V. Virkar;S.C. Singhal(Ed.);H. Iwahara(Ed.)
  14. J. Sol-gel Sci. Technol v.11 Two-Layer Fuel cell Electrolyte Structure by Sol-gel Processing K. Mehta;R. Xu;A.V. Virkar
  15. Materials for Electrochemical Energy Storage and Conversion Ⅱ-Batteries Capacities, and Fuel Cells, Mat. Res. Soc. Symp. Proc v.496 A Composite Electrolyte for an SOFC Consisting of a Ceria Sheet and A Zirconia Film Deposited by the Sol-gel Method R. Chiba;F. Yishimura;J. Yanaki;D.S. Kamura(Ed.);Z. Zhang(Ed.);B. Scrosati(Ed.)
  16. J. Am. Ceram. Soc. v.80 Fabrication and Sintering of Fine Yttria-Doped Ceria Powder J. Van herle;T. Horita;T. Kawada;N. Sakai;H. Yokokawa;M. Dokiya
  17. 요업학회지 v.35 전자 및 이온 전도성 CeO₂-Sm₂O₃고체 전해질 막의 합성 및 응용 현상훈;권재환;김승구;김계태
  18. J. Non-Crys. Solids v.100 Preparation of Alumina Fibers by Sol-Gel Method T. Maki;S. Sakka
  19. J. Non-Cryst. Solid v.48 The Sol-Gel Transition in the Hydrolysis of Metal Alkoxides in Relation to the Formation of Glass Fibers and Films S. Sakka;K. Kamiya
  20. J. Appl. Phys. v.49 Characteristics of Resist Films Produced by Spinning D. Meyerhofer